Installation Instruction

Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
S80 2011
S80 (07-) 2011

Instruction NoVersionPart. No.Click to download PDF-version of this Installation Instruction
307320011.231339076, 30732000
CD changer




 
Equipment
A0000162

IMG-222800

IMG-213320


 
  

INTRODUCTION

  • Read through all of the instructions before starting installation.

  • Notifications and warning texts are for your safety and to minimise the risk of something breaking during installation.

  • Ensure that all tools stated in the instructions are available before starting installation.

  • Certain steps in the instructions are only presented in the form of images. Explanatory text is also given for more complicated steps.

  • In the event of any problems with the instructions or the accessory, contact your local Volvo dealer.

1
IMG-214981
 

  • Turn the ignition key to position 0.

2
IMG-222805
 

    Remove the panel around the display and the media player:

  • Press in the catch at one of the panel's upper corners. Use a small screwdriver. Carefully prize off the radio panel on the same side. Use a plastic weatherstrip tool.

  • Carry out the same procedure on the other side. Then fold the radio panel backward in the vehicle.

  • Pull up the radio panel until it detaches.


    Hint

    If there is difficulty removing the panel, press the panel back into place on both sides and start the removal procedure again. Start from the opposite side to before.


3
IMG-222806
 

  • Remove the gear lever panel by carefully prizing it away starting at the rear edge and then continuing forward. It is fitted with six catches underneath.

4A
IMG-222807
4B
IMG-222811
 

    Illustrations A and B

  • Remove the gear lever panel from the gaiter by first pressing in the four catches at the sides, and then pull the panel up.

5
IMG-222804
 

  • Fold up the cover for the storage compartment in the rear section of the tunnel console.

6
IMG-222808
 

  • Remove the covers and screws in the rear edge of the upper panel section of the centre console, remove the screws on the rear of the panel and then remove the remaining screws on the top, ten in total.

7
IMG-232205
 

  • Remove the edge clip with cable from the lower section of the centre console.

8
IMG-232206
 

  • Carefully angle up the upper section of the centre console at the front edge so that the edge clip for the large cable harness on the left-hand side of the centre console is accessible.

  • Detach the clip with cable harness from its holder.


    Note!

    Do not damage the fibre optic cables and other cables.


9
IMG-232207
 

  • Angle the upper section further in order to access the four connectors on the rear of the climate control module (CCM).

  • Unplug the connectors. The connector (1) has a catch on the rear in toward the upper section.

10
IMG-222812
 

  • Remove the upper section of the panel by moving it backward at the front edge and then lifting it out from the rear edge of the tunnel console.

11
IMG-222813
 

  • Remove the two screws from the media player.

12
IMG-222814
 

  • Pull the media player out fully and unplug the connectors on the rear. Place the media player to one side, it shall not be used again.

13
IMG-222815
 

  • Take the new CD changer from the kit and plug the connectors into the rear.

  • Insert the CD changer into its location in the dashboard while making sure that the guide pins at the sides engage in the corresponding rails in the dashboard.

  • Guide the CD player in the guide pins on the front and tighten it in using the existing screws.

14
IMG-222816
 

  • Reinstall the upper section of the panel.

15
IMG-232284
 

  • Plug the connectors into the CCM unit.


    Note!

    Do not damage the fibre optic cables and other cables.


16
IMG-232285
 

  • Reinstall the edge clip with cable harness in the holder.

17
IMG-232286
 

  • Reinstall the edge clip with cable harness in the lower section of the centre console.

18
IMG-222817
 

  • Tighten the panel in using the existing screws.

  • Reinstall the covers on the screws at the rear edge.

19
IMG-222821
 

  • Reinstall the panel for the media player.

20A
IMG-222818
20B
IMG-222819
 

    Illustrations A and B

  • Reinstall the gear lever panel on the gaiter.

21
IMG-222820
 

  • Reinstall the panel with gaiter in the centre console.

22
IMG-222822
 

  • Fold back the cover for the storage compartment.